Product ID:DYNA-PRO SPRAY UNDERCOAT AND SEALER, 737
MSDS Date:09/28/1994
FSC:NIIN:Submitter:N EN
Status Code:A
MSDS Number: CKHJT

RPM-DYNATRON/BONDO CORP

3700 ATLANTA INDUSTRIAL PKWY
ATLANTA, GA 30331
US

Emergency Phone: (800)424-9300

Info Phone: 404-696-2730

Cage: 16522

BONDO/MAR-HYDE CORP

ATLANTA, GA 30331 US

Telephone: 404-696-2730

Cage: 16522

TOLUENE VP 22 MMHG

CAS: 108-88-3

RTECS: XS5250000

OSHA PEL see Table Z-2

ACGIH TLV: 188 MG/M3;50 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

MEDIUM ALIPHATIC SOLVENT NAPHTHA (PETROLEUM); (MINERAL

CAS: 8052-42-4

RTECS: CI9900000

ACGIH TLV: 5 MG/M3

72 PSIA @ 100F

CAS: 75-28-5

RTECS: TI4300000

124 PSIA @ 70F

CAS: 74-98-6

RTECS: TX2275000

OSHA PEL 1800 MG/M3;1000 PPM

Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: CONTACT W/LIQ OR VAP MAY
RESULT IN SEV IRRIT, REDNESS, TEARING & BLURRED VISION. SKIN:
CONTACT W/WET MATL MAY RESULT IN SEV IRRIT, DERM, DEFAT & BURNING
SENSATION. INHAL: EXCESSIVE INHAL OF VAPS MAY CAUSE NASAL & RESP
IRRIT, ACUTE NERVOUS SYS EFTS, FATG, WEAK, NAUS, HDCH, DIZZ, POSS
UNCON & EVEN ASPHYXIATION. INGEST: INGEST OF THIS MATL MAY CAUSE
DIARR, VOMIT & MUC MEMB DMG. ASPIR OF MATL INTO LUNGS DUE TO VOMIT
MAY PRDCE CHEM PNEUMONITIS WHICH CAN BE FATAL. CHRONIC: TOLUENE
APPEARS ON THE NAVY LISTING OF OCCUPATIONAL CHEM REPRO HAZS. SEEK
CONSULTATION FROM APPROP HEALTH PROFESSIO NALS CONCERNING LATEST
(EFTS OF OVEREXP)
Effects of Overexposure:HLTH HAZS: INFO & SAFE HANDLING & EXPOS INFO .
EXCESSIVE OVEREXP TO COMPONENTS OF THIS MATL HAS BEEN SUGGESTED TO
CAUSE LIVER ABNORMS IN HUMANS. OVEREXP TO COMPONENTS OF THIS MATL
HAS ALSO BEEN FOUND TO CAUSE FOLLOWING EFTS IN LAB ANIMALS: LIVER
ABNORMS, KIDNEY DMG, LUNG DMG, SPLEEN DMG & BRAIN DMG. IARC HAS
CLASSIFIED EXTRACTS OF STEAM & AIR REFINED BITUMENS (SUCH AS
CUTBACK ASPHALTS) AS PO SSIBLY CARCINOGENIC TO HUMANS (GROUP 2B)
BASED ON EXPERIMENTAL ANIMAL STUDIES. HUMAN STUDIES DID NOT PROVIDE
EVIDENCE THAT EXTRACTS OF STEAM & AIR-REFINED BITUMENS CAUSED
CANCER IN HUMANS.
Medical Cond Aggravated by Exposure:UNKNOWN.

First Aid:EYES: FLUSH IMMEDIATELY WITH LARGE AMOUNTS OF WATER FOR AT
LEAST 15 MINUTES. TAKE TO PHYSICIAN FOR MEDICAL TREATMENT. SKIN:
IMMEDIATELY WASH AFFECTED AREA WITH SOAP AND WATER. REMOVE
CONTAMINATED CLOT HNG. CONSULT A PHYSICIAN IF IRRITATION DEVELOPS.
INHALATION: REMOVE PERSON TO FRESH AIR. RESTORE BREATHING. KEEP
PERSON WARM AND QUIET. TREAT SYMPTOMATICALLY. GET MEDICAL
ATTENTION. INGESTION: DRINK O NE OR TWO GLASSES OF WATER TO DILUTE.
KEEP PERSON WARM AND QUIET. CONSULT A PHYSICIAN OR POISON CONTROL
CENTER IMMEDIATELY.

Flash Point Method:TCC
Flash Point:=15.6C, 60.F
LIQUID PORTION
Lower Limits:1.0%
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . WATER MAY BE USED TO COOL CONTAINERS TO PREVENT
PRESSURE BUILD-UP WHICH MAY RUPTURE CONTAINERS.
Unusual Fire/Explosion Hazard:PROPELLANT IS LIGHTER THAN AIR AND
EXTREMELY FLAMMABLE. CONTENTS ARE UNDER PRESSURE (APPROXIMATELY 55
+/- 5 PSI AT 70F). SOLVENT.

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE THE
AREA. WEAR PROTECTIVE EQUIPMENT. AVOID BREATHING VAPORS. CONTAIN
SPILL, ABSORB EXCESS WITH DRY INERT MATERIAL, REMOVE AND DISPOSE OF
PROPERLY.

Handling and Storage Precautions:STORE MATERIAL IN A COOL,
WELL-VENTILATED AREA. DO NOT STORE AT TEMPERATURES ABOVE 120F. DO
NOT USE OR STORE NEAR HEAT, SPARKS.
Other Precautions:KEEP OUT OF REACH OF CHILDREN. DO NOT TAKE
INTERNALLY. AVOID CONTACT WITH EYES AND SKIN. DO NOT PUNCTURE OR
INCINERATE AEROSOL CONTAINERS.

Respiratory Protection:USE NIOSH APPROVED RESPIRATORS DESIGNED TO
REMOVE PARTICULATE MATTER AND ORGANIC SOLVENT VAPORS.
Ventilation:GENERAL DILUTION OR LOCAL EXHAUST VENT SHOULD BE PROVIDED
TO KEEP EXPOSURES BELOW ACCEPTABLE LIMITS & TO KEEP SOLVENT VAPS
BELOW LOWER EXPLOSION LIMIT.
Protective Gloves:NEOPRENE OR NATURAL RUBBER GLOVES.
Eye Protection:ANSI APPROVED CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:ANSI APPROVED EYE WASH AND DELUGE SHOWER .
IMPERMEABLE CLOTHING SHOULD BE WORN TO PREVENT PROLONGED OR
REPEATED CONTACT OF WET MATERIAL WITH THE SKIN.
Work Hygienic Practices:ALWAYS WASH HANDS AFTER USING THIS MATERIAL AND
BEFORE EATING, DRINKING OR SMOKING.
Supplemental Safety and Health
FL PT: -156F(-104C) ESTIMATED FOR PROPELLANT ONLY. PHYSICAL DATA -
VAPOR DENSITY (AIR=1): PAINT-HEAVIER THAN AIR; PROPELLANT-LIGHTER
THAN AIR. EVAPORATION RATE: FASTER THAN ETHYL ETHER (PROPELLANT ONL
Y). WEIGHT PER GALLON: 7.735.

Boiling Pt:>-42.2C, -44.F
Vapor Pres:SEE INGREDIENTS
Vapor Density:SUPDAT
Spec Gravity:0.927
Evaporation Rate & Reference:SUPDAT
Percent Volatiles by Volume:73

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HIGH TEMPERATURES AND SOURCES OF IGNITION.
Hazardous Decomposition Products:HAZARDOUS FUMES MAY BE PRODUCED WHEN
MATERIAL IS HEATED TO DECOMPOSITION. FUMES MAY CONTAIN CARBON
MONOXIDE, CARBON DIOXIDE AND VARIOUS HYDROCARBONS.

Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH FEDERAL, STATE AND
LOCAL REGULATIONS. BEFORE ATTEMPTING CLEAN-UP OR DISPOSING OF
MATERIAL, REFER TO HAZARD INFORMATION IN OTHER SECTIONS OF THIS
SHEET. DO NOT INCINERATE AER OSOL CONTAINERS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Transport Information:DOT PROPER SHIPPING NAME: CONSUMER COMMODITY. DOT
HAZARD CLASS: ORM-D.

SARA Title III Information:TOLUENE IS SUBJECT TO THE REPORTING
REQUIREMENTS OF SARA TITLE III, PART 313.
State Regulatory Information:PROPOSITION 65: THIS PRODUCT CONTAINS A
CHEMICAL KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER, BIRTH
DEFECTS OR OTHER REPRODUCTIVE HARM.